1000kW Natural Gas Generator 480V Waukesha 7042GSI

Six (6) 1000kW Waukesha natural gas generators ready to ship. All components are brand-new **EXCEPT** for the Certified Waukesha re-manufactured engine, starter, and steel base skid. Can be configured for domestic (EPA) or export markets.

1) Certified Re-Manufactured Waukesha 7042GSI Natural Gas Engine
2) Air or Electric Start (optional, same cost)
3) Battery rack and cables, battery box (no batteries)
4) Battery Charger mounted in the switchgear
5) Block heaters with isolation valves (120/240V)
6) Steel Skid Base
7) 12-Lead PMG. two-bearing, close-coupled alternator, rated at 1000kW/1250kVA @ 1200RPM, 105°C Temperature Rise, 277/480V, 60 Hertz continuous duty, strip heaters, digital AVR. Configured for multi-unit synchronizing and parallel grid export operations, if required.
8) Engine to Alternator rubber-block drive coupling
9) Free Standing (off skid) NEMA3R generator set controller and switchgear package
10) ComAp digital paralleling and synchronizing controller. Safety shutdowns for high water temperature, low oil pressure, over crank, over speed, low radiator water level
11) Battery charger
12) Motor starting controls for electric drive radiator
13) 1600A air, rack-mounted draw-out motorized circuit breaker with PT’s and CT’s
14) Point of customer common contact bus bar connection inside the switch gear (access panel)
15) Utility grade relaying and protection
16) Service lighting inside the switch gear on twist timer
17) Clear Lexan viewing panel mounted for the switch gear door face
18) High quality NEMA 3R switch gear enclosure with high-quality stainless hinges and door locks, front and rear door entry. Powder coated paint
19) New wiring harness for command and control communications between engine and switch gear
20) Remote communications with DeepSea controller (available as standard)
21) Critical grade exhaust silencer complete with exhaust flex and transitions, bolt and gasket kit
22) Electric drive (horizontal discharge) separate-circuit (HT/LT) cooling radiator, rated for 50°C ambient, complete with motor starting controls. Mounted “off-skid” in front of the generator set package. Includes an installation kit for connection to the engine, shipped loose
23) Complete document package with installation instructions
24) Complete electrical & mechanical drawing package
25) Package shipped without fluids
26) High quality finish paint (Waukesha Orange)
27) Exhaust Catalyst (EPA domestic market)
28) AFR (Air-Fuel) controller
29) 1-year, 3000-hour warranty after site commissioning
30) Site commissioning is offered as an option.

NOTES:

a) 1200kW 7044GSI-S4 gensets are also available (limited stock)
b) Enclosure packages are available
c): Radiator features four (4) electric drive fans (as seen in 2nd photo)